An official website of the United States government
A .mil website belongs to an official U.S. Department of Defense organization in the United States.
A lock (lock ) or https:// means you’ve safely connected to the .mil website. Share sensitive information only on official, secure websites.

380AEW Article

Dirty Jobs: water and fuel systems maintenance

  • Published
  • By Staff Sgt. Colton Elliott
  • 380th Air Expeditionary Wing
AL DHAFRA AIR BASE, United Arab Emirates --  With waste water rising, base living quarters were about to be flooded until one Airman jumped into a pit of waste and began hooking up pumps to prevent the overflow.

Senior Airman Malachi Nemitz, 380th Expeditionary Civil Engineer Squadron water and fuels system maintenance specialist, noticed the lift station had failed and jumped in to figure out why the sewage wasn’t draining properly.

“I’ve only seen photos of lift stations at my technical training school,” said Nemitz, who is currently deployed from the 184th Intelligence Wing, Kansas Air National Guard. “I didn't know much about the system, but I couldn't just sit back and not do anything.”

The lift station that failed isn't maintained by the 380th ECES; however, it’s part of their daily routine to perform a visual inspection and make sure the station isn’t backing up.

According to Master Sgt. Matthew Fisher, 380th ECES water and fuels system maintenance noncommissioned officer in charge, all the wastewater on base leads to this one lift station that failed.

“Once we realized we were about to be flooded by our waste, our team went into full recovery mode,” said Fisher. “Airman Nemitz played a huge role in making sure the team remained positive. He always has a smile on his face even at times when nobody feels like being positive.”

The Water and Fuels Section temporarily contained the backed-up waste water by pumping it into tanker trucks and dumping it at the nearest pump station. This process went on for several days until they could diagnose where the root cause of the stoppage was located.

According to Nemitz, every time the pumps were connected or disconnected from the sewage trucks, the ECES Airmen working the issue would be showered with tiny particles of waste water.
Despite full-body personal protective gear keeping them clean Nemitz said, “It’s one of the dirtiest jobs, if not the dirtiest in the Air Force.”

While the team continued to manage the pits, the rest of the team focused on finding a solution to the problem.

“We followed the main pipe that takes all our contaminated water away,” said Fisher. “We had guys crawling into every man-hole for more than three miles to locate the blockage.”

After ten days of 24-hour operations, the water and fuels team found the blockage and replaced the defective pipes. The lift station began functioning properly by pumping waste again.

“We worked together as a team and no one complained about the long hours,” said Fisher. “Everyone knew what the consequences would have been if we couldn't complete our mission.”

According to Tech Sgt. Brandi Perryman, 380th Expeditionary Medical Group public health noncommissioned officer in charge, if the sewage didn't get cleaned up in the right way then base operations would have been shut down immediately.

“The dining facilities, latrines and showers would have all been closed,” said Perryman. “Everyone's hygiene would have been affected. Hand sanitizer can only do so much.”

The Water and Fuels Section ultimately pumped more than three million gallons of wastewater away from the base.

“If I have to get a little dirty every now and then, that’s why I’m here,” said Nemitz. “I take pride in knowing my team played a big role in supporting the mission here.”